• English 中文 全國免費熱線:135-0983-1315
    logo
     
    新鏵動態
    常見問題

    熱處理烤箱使用前注意事項

    來源: 最后更新:2023-08-01 12:00:43 作者:新鏵 瀏覽:459次

    危險:

    Warning

    一、 除特殊之安全型防爆烤箱(使用時須置于獨立之安全隔間內并嚴格禁止非相關人員隨意進出)以外,不可將加壓容器、爆裂物及下列表所示之易燃物、氧化物、發火物等物質置于烤箱內烘烤。

    Never put pressure container, bursts, and some as below listed for instance :Combustibles, oxide, inflammables etc. into oven, except specific safety type Flame-proof oven.

    Easy Combustibles Article List

    項目

    Item

    引火點

    Firing Point

    舉例物品

    Example

    1

    -30(-22°F)

    乙醚、汽油、乙醛、環氧丙烯、二硫化碳……等物質

    Ether、Gasoline、Acetaldehyde、Cyclpropene、cs2……etc.

    2

    高于-30(-22°F)低于0(32°F)

    Upper -30(-22°F), lower0(32°F)

    正已烷、環氧乙炔、丙酮、苯、丁酮………等物質

    Upper -30℃(-22°F), lower0℃(32°F)

    3

    高于0(-32°F)低于30(85°F)

    upper 0(-32°F), lower 30(85°F)

    甲醇、乙醇、二甲苯、醋酸、戊酯……….等物質

    Methy1 alcohol、Ethy1 alcohol 、Xylene、Acetic acid、Amy1 alcohol ………………etc.

    4

    高于30(-85°F)低于65(150°F)

    upper 30(-85°F) lower 65(150°F)

    煤油、柴油、松節油…………

    Kerosene、Diesel、Turpentine--etc.

          以上表格未能完全列出,請于烘烤前確認該烘烤物之成分及引火點以

          免發生危險。

    More materials not written list, so, must do check ingredients & firing point of bake material before start for safeties.

    二、 粉末、粉塵之加工物烘烤、訂購前請先告知以便特殊設計,以免引發燃燒危險!

     

    Some extra material as powder、dust by bake , please notice us before convenience specific design, avoidable dangers

    三、 務必接上進排風管,并須于每次開機時,確認進排風動作是否正常,并請定期檢測排風系統是否正常運作,否則無法正常排風亦會引發危險。

    Must connect in/out blower, and check function was normally by each start, then periodically test blower system keep running well, otherwise, dangers will occurring by exhaust abnormality.

    四、 烘烤物品若有揮發性溶劑殘留爐內,請定期清潔擦拭,避免殘留累積造成危險。

    Periodically clean solvent in oven wall, avoidable remain accumlate cause dangers.

    五、 請務必接地,如果不接地,當漏電事故發生時,會因漏電斷路器無法作動而造成觸電事故,接地時請按電工法規確實接地,不可將接地線接至瓦斯或水管上,亦不可將有漏電斷路器烤箱與無此裝置烤箱共享接地線路。

    Please connect the ground wire properly to earth ground to prevent leak.     according laws and regulations do it, don’t connect to gas or water pipe,

    especially not approval common ground wire to with ELB and without ELB.

    六、 如有漏電斷路器裝置時,須每月至少作一次測試漏電斷路器,以確定其是否可正常運作,以防萬一漏電而斷路器無法作用,亦有可能觸電,電磁接觸器請每年更換一次,以確保工作安全以及效率。

    Every month check ELB device one time at least, to affirm the function is normality to prevent leak Every month check ELB device one time at least, to affirm the function is normality to prevent leak

    七、 高溫運轉期間,或爐內溫度未降低至安全范圍,請不要打開爐門拿取烘烤物,以免高溫氣體吹出傷人或直接被烘烤物及烘箱內高溫燙傷,如須于高溫作業,請穿戴防護護具以防燙傷。

    Don’t open the door of oven take out material, when period in high temperature running or oven inside temperature not drop to safeties range, to prevent hurt somebody by high temperature air blow out, if need operation in high temperature stating must put on shelters to prevent scald.

    八、 排氣孔、閥、安全釋壓閥等附近請勿置放東西,以防止阻塞排氣造成危險。

    Don’t put anything in the vicinity of exhaust pipe、valve、safeties release valve to prevent obstruction exhaust cause dangers.

    九、 長期不用請拆下門扣及關閉電源,以防兒童或人員誤鎖于箱內造成危險,因一般之門扣無法由箱內開啟。

    When machine without use in long time, remember take off buckle and turn off power to prevent children or someone by mistake locked inside cause dangers, because normally can’t open the lock from inside.

    十、 第一次接上電源或移機重新接電時,請依電器銘板所示之電器規格接上電源,并須確實作好接地措施以防漏電意外。

    Please according mark and specification connect the power at first time use or moved machine connect the power again, and connect the ground wire properly to earth ground to prevent leak.

    十一、 確認送風馬達之轉向與指示之箭頭方向一致,以免循環不良導致危險。

    Check rotational direction of blower motor the same with indicate arrow, prevent circulation fault cause dangers.

    十二、 機身須保持水平,并與周圍間隔至少60公分以上,以利維修與散熱。

    Keeping horizontal of machine and away from wall 60cm at least, convenience for maintain and radiation.

    十三、 各機型不同亦有各需注意之事項,使用前務必詳閱說明書,以確保正常及安全的使用設備。

       Differ mode with distinct attention note, read carefully the entire manual

       before install machine for warrantable normality and safety to operation

       machine.

    0
    24小時銷售熱線:
    135-0983-1315
    官方微信二維碼
    手機網站
    • 新鏵機械-東莞
      電話:135-0983-1315 137-1258-7121(藍經理)
      郵箱:dgxhua@126.com
    • 臺灣
      電話:886-3-5687321 886-3-5687321(盛總)
      郵箱:dgxhcj@126.com
    • 越南辦事處
      電話: +84 16886888398(梅生)
      郵箱:dgxhcj@126.com
    • 廈門辦事處
      電話: 139-2557-9290(童生)
      郵箱:dgxhcj@126.com
    Copyright ? 2019東莞市新鏵機械設備有限公司
    粵ICP備13005774號
    | 網站地圖 | 產品中心 | 聯系我們

    服務熱線

    135-0983-1315

    功能和特性

    價格和優惠

    獲取內部資料

    微信服務號

    亚洲中文无码国产,亚洲Av中文无码乱人伦在线观看_ 亚洲AV乱码久久精品蜜桃,三级欧美少妇影视